Toyota FJ Cruiser

Issue: 
This recall is for certain block heater kits installed on certain vehicles or sold as accessories at Toyota or Lexus dealerships. 

On certain vehicles, the engine block heater cable may not have enough heat protection and could be damaged by high temperatures. If this happens, the cable could short circuit while plugged in, and cause the wiring to overheat or melt. 

Note: This recall only affects the following block heater/cord part numbers: 

C014003034                         PK5A408J09                         PU14000904 
C014003151                         PK5A408J13                         PU14000905 
C014000885                         PK5A489J11                         PU14000907 
C014000888                         PK5A489J22                         PU14000909 
C014000907                         PK5A410H00                        PU14000911 
C014100904                         PU14000900                         PU14000913 
C014100907                         PU14000901                         PU14003571 
C014100911                         PU14000902                         PK5A489J14 
PK5A408J05                        PU14000903 

Safety Risk: 
Engine block heater wiring that overheats or melts could create the risk of a fire. 

Corrective Actions: 
Toyota recommends that you should stop using the engine block heater immediately. Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to disable the engine block heater. For some vehicles, the corrective actions for this recall are under development. For others, a new engine block heater cannot be installed, and the owner will receive a refund of the purchase price of the engine block heater.

Issue: 
On certain vehicles, the low-pressure fuel pump could fail. If this happens, then engine may run rough or may not start and the check engine light may turn on. This could also result in a sudden loss of engine power while driving. 
Note: This recall is an expansion of recalls SRC R95/SRC R96 and SRC RA2/SRC RA3 (Transport Canada Recall Numbers 2020-005 and 2020-088). 
 
Safety Risk: 
A sudden loss of engine power could increase the risk of a crash.

Corrective Actions: 
The company will notify owners by mail and instruct you to take your vehicle to a dealer to replace the fuel pump.

Issue: 
On certain vehicles, the low-pressure fuel pump could fail. If this happens, then engine may run rough or may not start and the check engine light may turn on. This could also result in a sudden loss of engine power while driving. 
Note: This recall is an expansion of recall SRC R95/SRC R96 (Transport Canada Recall No. 2020-005) 
 
Safety Risk: 
A sudden loss of engine power could increase the risk of a crash.

Corrective Actions: 
The company will notify owners by mail and instruct you to take your vehicle to a dealer to replace the fuel pump.

On certain vehicles, the intermediate shaft that connects the steering wheel to the steering gear box might have been improperly welded during manufacturing.  If the vehicle is continuously operated in this condition, the weld could separate, which could result in a loss of steering control, increasing the risk of a crash causing injury and/or damage to property.  Correction:  Dealers will replace the intermediate shaft.

On certain vehicles, due to insufficient strength of the access door (rear door) panels, cracks may develop if the access doors are repeatedly and forcefully closed over an extended period of time. As the driver and front passenger seat belt retractors are mounted in the access door panels, if cracks occur in the panel around the lower retractor anchor, the seat belt retractors could become detached. This could increase the risk of injury to an occupant in the event of a crash. Correction: Dealers will inspect the rear door panels for cracks or separation. Depending on the results of the inspection, the dealer will repair as necessary.