2013 Toyota Venza

Issue: 
This recall is for certain block heater kits installed on certain vehicles or sold as accessories at Toyota or Lexus dealerships. 

On certain vehicles, the engine block heater cable may not have enough heat protection and could be damaged by high temperatures. If this happens, the cable could short circuit while plugged in, and cause the wiring to overheat or melt. 

Note: This recall only affects the following block heater/cord part numbers: 

C014003034                         PK5A408J09                         PU14000904 
C014003151                         PK5A408J13                         PU14000905 
C014000885                         PK5A489J11                         PU14000907 
C014000888                         PK5A489J22                         PU14000909 
C014000907                         PK5A410H00                        PU14000911 
C014100904                         PU14000900                         PU14000913 
C014100907                         PU14000901                         PU14003571 
C014100911                         PU14000902                         PK5A489J14 
PK5A408J05                        PU14000903 

Safety Risk: 
Engine block heater wiring that overheats or melts could create the risk of a fire. 

Corrective Actions: 
Toyota recommends that you should stop using the engine block heater immediately. Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to disable the engine block heater. For some vehicles, the corrective actions for this recall are under development. For others, a new engine block heater cannot be installed, and the owner will receive a refund of the purchase price of the engine block heater.

Issue: 
On certain vehicles, the wiring for the airbag sensor in the driver's door could be damaged over time. If this happens, the side airbag and curtain airbag on the driver's side may not work properly in a crash. 
Note: This problem may cause the SRS warning lamp to turn on in the instrument cluster. 

Safety Risk: 
Airbags that do not work properly could create an increased risk of injury in a crash. 

Corrective Actions: 
Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the driver's door wire harness. It will be replaced, if necessary.

On certain vehicles, if the air conditioning condenser drain hose were to become clogged, water could accumulate and leak onto the airbag control module. This could cause the airbag warning light to illuminate, and potentially result in an unintended deployment of the airbags. This could startle the driver and/or cause minor injuries to vehicle occupants. Water damage could also cause a loss of power steering assist, causing the vehicle to revert to a manual steering mode which would require greater driver effort, especially at low vehicle speeds, and increase the risk of a crash causing injury and/or damage to property. Correction:  Dealers will install a protective shield and sealant.