2003 GMC Savana 1500 Passenger

Issue: 
On certain vehicles, an unused wiring harness for a rear HVAC blower motor, located in the left B-pillar area, could become damaged if exposed to moisture or contaminants. If this happens, the wires could short circuit.
Note: This recall only affects cutaway chassis incomplete vehicles.  

Safety Risk: 
A short circuit can create the risk of a fire. 

Corrective Actions: 
General Motors will notify owners by mail and instruct you to bring your vehicle to a dealership to seal the wiring for the rear HVAC blower motor at the left B-pillar.

On certain vehicles equipped with a left side cargo door, and originally sold in or currently operated in areas of heavy road salt usage during winter months (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador), the fuel filler pipe could corrode and become perforated.  This could allow fuel to leak onto the ground while refuelling the vehicle.  Fuel leakage, in the presence of an ignition source, could result in a fire causing property damage and/or personal injury.  Correction: Dealers will replace the fuel filler pipe.

Certain full-size passenger, cargo and cutaway vans may have front and rear seat belt buckles that will not latch or will not unlatch.  There are two conditions that render the buckle inoperative after customer usage.  Specifically, (1) with a damaged ejector hood, the latch tongue cannot fully enter the buckle and will not latch, and (2) if the release bar moves permanently out of position the buckle will either be unable to engage the latch or the pushbutton will be unable to unlatch the buckle.  Correction: Dealers will inspect buckles and, if found to be inoperative, the entire buckle assembly will be replaced.  Note: This is an expansion of recall 2005390.

Certain full-size passenger, cargo and cutaway vans may have front and rear seat belt buckles that will not latch or will not unlatch.  There are two conditions that render the buckle inoperative after customer usage.  Specifically, (1) with a damaged ejector hood, the latch tongue cannot fully enter the buckle and will not latch, and (2) if the release bar moves permanently out of position the buckle will either be unable to engage the latch or the pushbutton will be unable to unlatch the buckle.  Correction: Dealers will inspect buckles and, if found to be inoperative, the entire buckle assembly will be replaced.

On certain vehicles, the transmission shift cable may allow the transmission indicator (PRNDL) to indicate a different gear selected than the transmission is in.  If this condition occurred while a vehicle is resting on an uneven surface, the vehicle could roll away after the driver has exited.  Correction:  Dealer will inspect and replace the transmission shift cable assembly.