2014 BMW i3

Issue: 
On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". Canadian regulations require the information to be listed on the label in both English and French. 

Safety Risk: 
This error does not affect vehicle safety. 

Corrective Actions: 
This is not a recall. The company has corrected the tire and loading information label for all new vehicles.

On certain i3 REX models, a section of the fuel tank vent line could chafe against an adjacent ribbed wire protector. Over time, this chaffing could lead to the fuel tank vent line wearing through and leaking. Due to enclosed engine compartment of this vehicle and elevated underhood temperatures, this could increase the risk of a fire causing injury and/or property damage. Correction: Dealers will install a clip between the fuel tank vent line and the adjacent ribbed wire protector to prevent contact, and the fuel tank vent line will be inspected and replaced as necessary.

Certain vehicles may not comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 208 - Occupant Protection in Frontal Impacts.  The internal components of the passenger frontal airbag inflator may not have been assembled properly during manufacturing.  The passenger frontal airbag’s first stage (only) deployment could be affected, delaying the deployment timing of the second stage.  This could result in the right front occupant not receiving the intended protection from the frontal airbag in a low speed or out-of-position crash, increasing the risk of injury to the occupant where airbag deployment is warranted.  Correction: Dealers will replace the passenger frontal airbag module.

Certain vehicles, which were parked at the port of entry in Halifax during the ice storms in February 2015, may have been exposed to excessive standing water and salt for an extended period due to this isolated environmental incident. Certain MINI models could have corrosion at the starter motor power supply cable connectors, which could lead to the inability to restart the engine following an engine shutdown by the start-stop (MSA) system, increasing the risk of crash causing injury in a traffic situation. On certain BMW models, the lubrication of some internal components within the steering rack may have been exposed to excessive water or salt which could result in higher than normal steering effort or steering binding, increasing the risk of a crash causing injury and/or damage to property. In addition, electrical wires and/or connectors in all affected vehicles may have been exposed to water or salt, which could lead to increased electrical system resistance, and increase the risk of fire causing injury and/or damage to property. 

Correction: Owners should contact their selling Retailer regarding this recall.  Affected vehicles will be inspected. Some vehicles will be taken out of service immediately and owners will be provided with temporary transportation until a new replacement vehicle is available. All other vehicles are cleared of this safety concern and may continue to be driven until a new replacement vehicle is available. Due to potential concerns about long term vehicle quality, all affected vehicles will ultimately be removed from service.