2008 Volkswagen Passat

On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, could eventually degrade the propellant contained in the driver frontal airbag. This could cause the airbag to deploy with more force than normal. As a result, if the vehicle were involved in a collision that warrants airbag deployment, fragments could be propelled toward vehicle occupants, and the airbag assembly could be damaged, preventing proper function. These issues could increase the risk of injury. Correction: Dealers will replace the driver frontal airbag inflator. Note: Canadian climate results in the propellant degrading slowly. The recall is being conducted as a precaution to address future risk, and is expected to replace airbag inflators before their function would be affected. Additional Note: This recall supersedes the Volkswagen brand vehicles subject to recall 2016-064 (Volkswagen Recall 69M9). Volkswagen vehicles completed under the previous 2016-064 recall require repair under this recall, as the previous recall remedy was an interim repair. Interim repair parts must be replaced with final repair parts.

On certain vehicles, there could be an interruption in electrical power to the fuel pump control module. This could result in the fuel pump running continuously, resulting in a drained battery and/or a no start condition, or cause a loss of motive power while the vehicle is in motion, which could increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace the fuel pump control module and relocate it within the vehicle.

On certain vehicles, the driver frontal airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Correction: Dealers will replace the front driver airbag inflator. Note: This campaign only affects the Audi A5 and Audi S5 Cabriolet models.

On certain Passat and Passat wagon, the Engine Control Module (ECM) contains software that may not properly control engine speed with the air conditioning turned on.  The ECM may briefly increase engine RPM and vehicle speed.  A vehicle surge caused by an unexpected increase in engine RPM may surprise the vehicle operator and can result in a crash causing property damage, personal injury or death.  Correction: Dealers will inspect and, if necessary, update the ECM software.