2005 Dodge Caravan C/V

Issue: 
This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. 
Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. 

Safety Risk: 
Glass that breaks in to large pieces could create a risk of injury. 
 
Corrective Actions: 
The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.

On certain vehicles the left or right front supplemental airbag sensors may crack under certain conditions, which can allow water to enter into the sensor.  This can cause the airbag warning lamp to illuminate.  A malfunction of one or both of the supplemental sensors will not adversely affect safety or cause a failure to comply with government standards.  The single-point sensor in these vehicles, which is located in the airbag control module, is operational even if both supplemental sensors are inoperative.   DaimlerChrysler has decided to launch a Customer Satisfaction Notification to advise customers that these front airbag sensors will be replaced with redesigned sensors to reduce the potential for damage. This action is not being conducted under the Motor Vehicle Safety Act.

On certain vehicles, the front windshield wiper motor armature shaft may break which could result in a loss of front windshield wiping capability.  This could impair the driver's vision and cause a crash without warning.  Correction: Dealers will inspect and, if necessary, replace the front windshield wiper motor.

On certain vehicles, the front passenger seat belt retractor may have been improperly assembled.  During a severe frontal impact, there is a possibility that the seat belt may not properly restrain the occupant which can increase the risk of injury.  Correction:  Dealer will inspect the retractor assembly, and replace if necessary.