2012 Dodge Avenger

Issue: 
This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. 
Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. 

Safety Risk: 
Glass that breaks in to large pieces could create a risk of injury. 
 
Corrective Actions: 
The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.

On certain vehicles, there could be an electrical condition within the Occupant Restraint Control ("ORC") module. This may result in the airbag warning lamp illuminating, and the active head restraints not to deploy during certain rear impact collisions, which could increase the risk of injury to front seat occupants. Correction: Dealers will inspect the ORC part number and replace the ORC if necessary. Note: Vehicles that have been previously repaired with the updated ORC under recall 2016-448 will not require repairing under this recall campaign.

On certain vehicles in certain types of crashes, airbag and seatbelt pretensioner deployment capability may be lost due to a short in the front impact sensor wiring affecting Occupant Restraint Controller function. Failure of airbags and seatbelt pretensioners to deploy in a crash (when warranted) could increase the risk of injury. Correction: Dealers will replace the Occupant Restraint Controller module.

On certain vehicles, the airbag warning lamp may illuminate due to an electrical fault within the Occupant Restraint Control (ORC) module.  As a result, the Active Head Restraints (AHR) may not deploy during a rear impact collision (where deployment is warranted), which could increase the risk of personal injury to the front seat occupants.  Correction: Dealers will reprogram the Totally Integrated Power Module (TIPM) or replace the ORC module, as required.